EMC Test Report. Client: Crestron Electronics, Inc. Tested by: Jeremy O. Pickens, Senior EMC Engineer

Transcription

1 Test Report Number: EMC1 Rev. Page: 1 of 26 EMC Test Report Project Number: Report Number: EMC1 Revision Level: Client: Crestron Electronics, Inc. Equipment Under Test: infinet EXTM Gateway Model Number: CENI-GWEXER / CEN-GWEXER-PWE Applicable Standards: EN v1.9.1 (215-2) Report issued on: 9 February 216 Test Result: Compliant Tested by: Jeremy O. Pickens, Senior EMC Engineer Reviewed by: David Schramm, EMC/RF/SAR/HAC Manager Remarks: This report details the results of the testing carried out on one sample, the results contained in this test report do not relate to other samples of the same product. The manufacturer should ensure that all products in series production are in conformity with the product sample detailed in this report. This report may only be reproduced and distributed in full. If the product in this report is used in any configuration other than that detailed in the report, the manufacturer must ensure the new system complies with all relevant standards. Any mention of SGS International Electrical Approvals or Testing done by SGS International Electrical Approvals in connection with distribution or use of the product described in this report must be approved by SGS international Electrical Approvals in writing.

2 Table of Contents Test Report Number: EMC1 Rev. Page: 2 of 26 1 SUMMARY OF TEST RESULTS MODIFICATIONS REQUIRED FOR COMPLIANCE GENERAL INFORMATION CLIENT INFORMATION TEST LABORATORY GENERAL INFORMATION OF EUT OPERATING MODES AND CONDITIONS RADIATED SYSTEM CONFIGURATION EUT CONNECTION BLOCK DIAGRAM CONDUCTED TESTING CONDUCTED SYSTEM CONFIGURATION RF OUTPUT POWER TEST RESULT TEST METHOD TEST EQUIPMENT TEST DATA POWER SPECTRAL DENSITY TEST RESULT TEST METHOD TEST DATA OCCUPIED CHANNEL BANDWIDTH TEST METHOD TEST EQUIPMENT TEST DATA TRANSMITTER UNWANTED EMISSIONS IN THE OUT-OF-BAND DOMAIN TEST RESULT TEST METHOD TEST EQUIPMENT TEST DATA TRANSMITTER SPURIOUS EMISSIONS TEST RESULT TEST METHOD TEST EQUIPMENT TEST DATA RECEIVER SPURIOUS EMISSIONS TEST METHOD TEST EQUIPMENT TEST DATA REVISION HISTORY SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

3 Test Report Number: EMC1 Rev. Page: 3 of 26 1 Summary of Test Results Test Description Test Specification Test Result RF Output Power EN Compliant Duty Cycle / Tx Sequence / Tx-Gap / Medium Utilisation EN NA(1) Power Spectral Density EN Compliant Accumulated Transmit Time, Occupation and Hopping Sequence EN NA(2) Hopping Separation EN NA(2) Adaptivity(Channel access mechanism) EN NA(1) Occupied Channel Bandwidth EN Compliant Transmitter unwanted emissions in the outof-band domain EN Compliant Transmitter unwanted emissions in the spurious domain EN Compliant Receiver Spurious Emissions EN Compliant NA: (1) Not Applicable to devices where the RF Output power (nominal temperature and voltage) is less than 1 dbm e.i.r.p. (2) Not Applicable to DTS devices. 1.1 Modifications Required for Compliance None 2 General Information 2.1 Client Information Name: Crestron Electronics, Inc. Address: 15 Volvo Drive City, State, Zip, Country: Rockleigh, NJ 7647, USA 2.2 Test Laboratory Name: SGS North America, Inc. Address: 62 Old Peachtree Road NW, Suite 1 City, State, Zip, Country: Suwanee, GA 324, USA Accrediting Body: A2LA Type of lab: Testing Laboratory Certificate Number: Environmental Conditions From: January 22, 216 February 4, 216 Temperature: Minimum: 23.9 C Maximum: 24.9 C Relative Humidity: Minimum: 24.6% Maximum: 17.2% SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

4 Test Report Number: EMC1 Rev. Page: 4 of General Information of EUT Type of Product: infinet EX TM Gateway Model Number: CENI-GWEXER Serial Number: Not labeled Firmware Version: v Test Voltage: Vdc Extremes, 24Vdc Nominal Range: 245 to 248 MHz Number of channels: Operating Modes and Conditions The EUT was configured with software to allow the EUT to be manually placed in continuous transmit mode on any channel (11-26, MHz). 2.5 Radiated System Configuration A B Device reference Manufacturer Description Model Number Serial Number A Crestron infinet EX TM Gateway CEN-GWEXER Not Labeled B Crestron 24Vdc Power Supply NBS24J2475D5 Not Labeled SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

5 2.6 EUT Connection Block Diagram Conducted Testing Test Report Number: EMC1 Rev. Page: 5 of 26 A B C 2.7 Conducted System Configuration Device reference Manufacturer Description Model Number Serial Number A Crestron infinet EX TM Gateway CEN-GWEXER Not Labeled B Extech DC power supply EA3 C Rohde & Schwarz Test System TS8997 NSN SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

6 Test Report Number: EMC1 Rev. Page: 6 of 26 3 RF Output Power 3.1 Test Result Test Description Test Specification Test Result RF Output Power Compliant 3.2 Test Method The test data was measured using the conducted measurement method as described in clause For extreme operating conditions the manufacturers declared environmental operational range of 1 C to +4 C and a voltage range of Vdc was used. Limit The maximum RF output power for non-adaptive equipment shall be declared by the supplier and shall not exceed 2 dbm. This limit shall apply for any combination of power level, intended antenna assembly, and extreme operating condition. 3.3 Test Equipment Test Start Date: 3-Feb-216 Test End Date: 4-Feb-216 Tester: JOP Equipment Model Manufacturer Asset Number Cal Due Date SIGNAL ANALYZER FSV3 ROHDE & SCHWARZ B Oct-217 OPEN SWITCH AND CONTROL PLATFORM OSP12 ROHDE & SCHWARZ S/N: CNR SIGNAL GENERATOR SMB-1A ROHDE & SCHWARZ S/N: CNR ENVIRONMENTAL TEST CHAMBER T2RC TENNEY ENVIRONMENTAL B94877 CNR TRUE RMS MULTIMETER 87V FLUKE B Aug-216 DC POWER SUPPLY EXTECH EA3 1-Apr-216 Calibration interval is 1 year. FSV Signal Analyzer was used to validate the OSP and Signal Generator prior to testing. Fluke thermometer used to verify temperature settings in the environmental chamber. 3.4 Test Data Measured Power (dbm) Channel MHz Setting (dbm) 1 C 22 C 4 C Voltage (Vdc) Pass/Fail Max PASS Max PASS Max PASS Duty Cycle Corr Ant Gain (dbi) Highest EIRP dbm Spec Limit, dbm SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

7 Test Report Number: EMC1 Rev. Page: 7 of 26 4 Power Spectral Density 4.1 Test Result Test Description Test Specification Test Result Power Spectral Density Compliant 4.2 Test Method Measurements were recorded using an automated Rhode & Schwarz TS8997 Regulatory Test System fitted with a spectrum analyzer. The analyzer was used to collect data points across the entire band ( MHz). Each point was summed, and the average was normalized to the measured RF output power. Then each 1 MHz band of points was individually summed and the highest result was recorded as the measured PSD in dbm/mhz. Limit The maximum e.i.r.p. spectral density is limited to 1dBm/MHz. This limit shall apply for any combination of power level and intended antenna assembly. 4.3 Test Data Because the measured RF output power at nominal temperature and volatge was less than 1dBm EIRP, it was not necessary to perform power spectral density measurements. SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

8 5 Occupied Channel Bandwidth Test Report Number: EMC1 Rev. Test Description Test Specification Test Result Occupied channel bandwidth Compliant Page: 8 of Test Method Measurements were recorded using an automated Rhode & Schwarz TS8997 Regulatory Test System fitted with a spectrum analyzer. The measurement was performed at the lowest and highest channels for each modulation type using the conducted measurement method defined in Section Limit: The Occupied Channel Bandwidth shall fall completely within the band given in clause 1 (2.4 GHz to GHz). For non-adaptive Hopping equipment with e.i.r.p greater than 1 dbm, the Occupied Channel Bandwidth for every occupied hopping frequency shall be equal to or less than the value declared by the supplier. This declared value shall not be greater than 5 MHz. For non-adaptive systems using wide band modulations other than FHSS and with e.i.r.p greater than 1 dbm, the occupied channel bandwidth shall be less than 2 MHz. 5.2 Test Equipment Test Date: 3-Feb-216 Tester: JOP Equipment Model Manufacturer Asset Number Cal Due Date SIGNAL ANALYZER FSV3 ROHDE & SCHWARZ B Oct-217 OPEN SWITCH AND CONTROL PLATFORM OSP12 ROHDE & SCHWARZ S/N: CNR SIGNAL GENERATOR SMB-1A ROHDE & SCHWARZ S/N: CNR TRUE RMS MULTIMETER 87V FLUKE B Aug-216 DC POWER SUPPLY EXTECH EA3 1-Apr-216 SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

9 Level in dbm Level in dbm Test Report Number: EMC1 Rev. Page: 9 of Test Data Low DUT (MHz) DUT Bandwidth (MHz) DUT Port Channel Center (MHz) Occupied Channel Bandwidth (MHz) Result PASS PASS Frequenc y in M H z High Frequenc y in M H z SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

10 Test Report Number: EMC1 Rev. Page: 1 of 26 6 Transmitter unwanted emissions in the out-of-band domain 6.1 Test Result Test Description Test Specification Test Result OOB Domain Compliant 6.2 Test Method Measurements were recorded using an automated Rhode & Schwarz TS8997 Regulatory Test System fitted with a spectrum analyzer. The measurement was performed at the lowest and highest channels for each modulation type using the conducted measurement method defined in Section Limit 6.3 Test Equipment Test Start Date: 3-Feb-216 Test End Date: 4-Feb-216 Tester: JOP Equipment Model Manufacturer Asset Number Cal Due Date SIGNAL ANALYZER FSV3 ROHDE & SCHWARZ B Oct-217 OPEN SWITCH AND CONTROL PLATFORM OSP12 ROHDE & SCHWARZ S/N: CNR SIGNAL GENERATOR SMB-1A ROHDE & SCHWARZ S/N: CNR ENVIRONMENTAL TEST CHAMBER T2RC TENNEY ENVIRONMENTAL B94877 CNR TRUE RMS MULTIMETER 87V FLUKE B Aug-216 DC POWER SUPPLY EXTECH EA3 1-Apr-216 Note: The calibration period equipment is 1 year. SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

11 Test Report Number: EMC1 Rev. Page: 11 of Test Data 22 C, 24Vdc Low High SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

12 Test Report Number: EMC1 Rev. Page: 12 of 26 1 C, 22.8Vdc Low High SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

13 Test Report Number: EMC1 Rev. Page: 13 of 26 1 C, 25.2Vdc Low High SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

14 Test Report Number: EMC1 Rev. Page: 14 of 26 4 C, 22.8Vdc Low High SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

15 Test Report Number: EMC1 Rev. Page: 15 of 26 4 C, 25.2Vdc Low High SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

16 Test Report Number: EMC1 Rev. Page: 16 of 26 7 Transmitter Spurious Emissions 7.1 Test Result Test Description Test Specification Test Result Transmitter Spurious Emissions Clause Compliant 7.2 Test Method Initial measurements were taken using the conducted methods defined in clause Any emissions falling within 6dB of the limit were then measured using the methods in clause Testing was repeated using the radiated methods defined in clause Tests were performed at the lowest and highest channels. Limit 7.3 Test Equipment Test Date: 22-Jan-216 Tester: FL Equipment Model Manufacturer Asset Number Cal Due Date EMI TEST RECEIVER ESU4 ROHDE & SCHWARZ B Aug-216 PREAMPLIFIER-ANTENNA SYS TS-PR18 ROHDE & SCHWARZ Aug-216 DRG HORN (MEDIUM) 3117 ETS-LINDGREN B Jul-216 RF CABLE NMS NMS FLORIDA RF LABS B952 4-Aug-216 RF CABLE NFS NFS FLORIDA RF LABS B Aug-216 RF CABLE SF16 HUBER&SUHNER B Aug-216 ANTENNA, BILOG JB6 SUNOL B Sep-216 Note: The calibration period equipment is 1 year. SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

17 Amplitude dbm Amplitude dbm 7.5 Test Data There were no emissions within 1dB of the limits. Channel 11 (245MHz) Vertical Radiated Emissions Plot 3-3MHz Test Report Number: EMC1 Rev. Page: 17 of 26-2 R SE - Vertical 245MH z, C h 11 - Tx Mode M 1.M 1.G 3.G Info:: C reston / Channel 11 (245MHz) Horizontal Radiated Emissions Plot 3-3MHz -2 RSE - Horizontal 245MHz, Ch 11 - Tx Mode M 1.M 1.G 3.G Info:: Creston / SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

18 Amplitude dbm Amplitude dbm Channel 11 (245MHz) Vertical Radiated Emissions Plot GHz Test Report Number: EMC1 Rev. Page: 18 of 26 R SE - Vertical 245MH z C h 11 - TX Mode G 1.G 12.75G Info:: C reston Channel 11 (245MHz) Horizontal Radiated Emissions Plot GHz RSE - Horizontal 245MHz Ch 11 - TX Mode G 1.G 12.75G Info:: Creston SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

19 Amplitude dbm Amplitude dbm Channel 26 (248MHz) Vertical Radiated Emissions Plot 3-3MHz Test Report Number: EMC1 Rev. Page: 19 of 26-2 R SE - Vertical 248MH z, C h 26 - Tx Mode M 1.M 1.G 3.G Info:: C reston / Channel 26 (248MHz) Horizontal Radiated Emissions Plot 3-3MHz -2 RSE - Horizontal 248MHz, Ch 26 - Tx Mode M 1.M 1.G 3.G Info:: Creston / SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

20 Amplitude dbm Amplitude dbm Channel 26 (248MHz) Vertical Radiated Emissions Plot GHz Test Report Number: EMC1 Rev. Page: 2 of 26 R SE - Vertical 248MH z C h 26 - TX Mode G 1.G 12.75G Info:: C reston Channel 26 (248MHz) Horizontal Radiated Emissions Plot GHz RSE - Horizontal 248MHz Ch 26 - TX Mode G 1.G 12.75G Info:: Creston SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

21 8 Receiver spurious emissions Test Report Number: EMC1 Rev. Test Description Test Specification Test Result Receiver spurious emissions Clause Compliant Page: 21 of Test Method Using a spectrum analyzer measurements were taken via the radiated method as described in clause of the standard. Tests were performed at the lowest and highest channels. 8.2 Test Equipment Test Date: 22-Jan-216 Tester: FL Equipment Model Manufacturer Asset Number Cal Due Date EMI TEST RECEIVER ESU4 ROHDE & SCHWARZ B Aug-216 PREAMPLIFIER-ANTENNA SYS TS-PR18 ROHDE & SCHWARZ Aug-216 DRG HORN (MEDIUM) 3117 ETS-LINDGREN B Jul-216 RF CABLE NMS NMS FLORIDA RF LABS B952 4-Aug-216 RF CABLE NFS NFS FLORIDA RF LABS B Aug-216 RF CABLE SF16 HUBER&SUHNER B Aug-216 ANTENNA, BILOG JB6 SUNOL B Sep-216 Note: The calibration period equipment is 1 year. SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

22 Amplitude dbm Amplitude dbm Test Report Number: EMC1 Rev. Page: 22 of Test Data There were no emissions within 6dB of the limits. Channel 11 (245MHz) Vertical Radiated Emissions Plot 3-3MHz -3 RSE - Vertical Ch 11 (245MHz) - Rx Mode M 1.M 1.G 3.G Fr equency Info:: Cr estr on Channel 11 (245MHz) Horizontal Radiated Emissions Plot 3-3MHz -3 RSE - Horizontal C h 11 (245MH z ) - R x Mode M 1.M 1.G 3.G Info:: C restron SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

23 Amplitude dbm Amplitude dbm Channel 11 (245MHz) Vertical Radiated Emissions Plot GHz Test Report Number: EMC1 Rev. Page: 23 of 26-3 RSE - Vertical 245MHz Ch 11 - RX Mode G 1.G 12.75G Fr equency Info:: Cr eston Channel 11 (245MHz) Horizontal Radiated Emissions Plot GHz -3 RSE - Horizontal 245MH z C h 11 - R X Mode G 1.G 12.75G Info:: C reston SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

24 Amplitude dbm Amplitude dbm Channel 26 (248MHz) Vertical Radiated Emissions Plot 3-3MHz Test Report Number: EMC1 Rev. Page: 24 of 26-3 RSE - Vertical Ch 26 (248MHz) - Rx Mode M 1.M 1.G 3.G Fr equency Info:: Cr estr on Channel 26 (248MHz) Horizontal Radiated Emissions Plot 3-3MHz -3 RSE - Horizontal C h 26 (248MH z ) - R x Mode M 1.M 1.G 3.G Info:: C restron SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

25 Amplitude dbm Amplitude dbm Channel 26 (248MHz) Vertical Radiated Emissions Plot GHz Test Report Number: EMC1 Rev. Page: 25 of 26-3 RSE - Vertical 248MHz Ch 26 - RX Mode G 1.G 12.75G Fr equency Info:: Cr eston Channel 26 (248MHz) Horizontal Radiated Emissions Plot GHz -3 RSE - Horizontal 248MH z C h 26 - R X Mode G 1.G 12.75G Info:: C reston SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)

26 9 Revision History Test Report Number: EMC1 Rev. Page: 26 of 26 Revision Level Description of changes Revision Date Initial release 9 February 216 SGS North America Inc. Consumer Testing Services 62 Old Peachtree Road NW, Suite 1, Suwanee, GA 324 t (77)