Gear Rack set 5.33 Product No. 20090096 4. Remove the motor. (If motor is stuck, small adjustments of legs will help.) (4 mm) 5. Disassemble the cover profile (A) and the lower stop screw (B) and nut. A B Stop screw, lower (M8X16) 5 mm+ 13 mm 6. Remove both legs. (4 mm) (17 mm) Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 43 www.liko.com l www.hill-rom.com
Gear Rack set 5.33 Product No. 20090096 7. If applicable: Disassemble the cover profile and the upper stop screw and the square nut. Applicable for Golvo produced from Dec. 2014 and Golvo with middle beam replaced with spare part 20090094 or 20090095. Stop screw, upper (M6x8) B A T30 + 8. Pull apart the legs from the middle beam and remove the gear racks. 9. Make sure the friction plates are in place. Spare Part 20090072 Friction plates 2.8-3.4 mm. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 44 www.liko.com l www.hill-rom.com
7000 68 70 Gear Rack set 5.33 Product No. 20090096 10. Grease the racks and the friction plates with Fluorflon PTFE grease. Assemble the slipper. Fixate the nut in the slipper with Locktite 460 Mount the slipper in a straight line with middle beam track. 11. Grease the gear rack and friction plates with Flouron PTFE grease. Replace the gear racks. 12 ± 3 Nm (106 ± 27 In lbf) Insert the left gear rack into the middle beam. 78 80 82 84 86 88 90 92 94 96 Gear rack on middle beam with label. 76 72 74 Gear rack on middle beam with no label. Insert the right gear rack (with label) into the middle beam. 12. If applicable: Assemble the upper stop screw and the square nut. Stop screw, upper (M6x8) IMPORTANT! Corner of the nut against the profile edge. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 45 www.liko.com l www.hill-rom.com
Gear Rack set 5.33 Product No. 20090096 13. Assemble the lower stop screw and nut. B A Stop screw, lower (M8X16) 5 mm+ 13 mm IMPORTANT! Flat edge side of the nut (A) facing the rack (B). 14. Reassemble both legs. (4 mm) (17 mm) 15. Reassemble the motor. (4 mm) Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 46 www.liko.com l www.hill-rom.com
Gear Rack set 5.33 Product No. 20090096 16. Assemble the cover profile. Reassemble the mast, battery and cables according to step 3, 2, and 1. 17. After assembly: The distance A & B must be the same. A B - Assembly of the base widening is safety critical. - Make sure the parts is mounted according to the assembly instruction. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 47 www.liko.com l www.hill-rom.com
5.36 Spring Magazine Fjäderkassett Spring magazine 1 Golvo 7000/7007 (all models) Golvo 8000/8008 (all models) Masterlift 2200, 2300 Likorall 240, 242, 242S, 242ES Prod. No. 20090041 3SE630214-04 2010-05-04 Remove after assembly - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 48 www.liko.com l www.hill-rom.com
5.37 Front Wheel 50 mm Framhjul 50 mm Prod. No. 20090042 1. 17 mm 2. 3. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 49 www.liko.com l www.hill-rom.com
5.38 Front Wheel 100 mm Framhjul 100 mm Prod. No. 20090043 1. 17 mm 2. 3. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 50 www.liko.com l www.hill-rom.com
5.39 Real Wheel 75 mm Bakhjul 75 mm Lockable castor, d=75 mm 1 Nut M12 1 Golvo 1000,2000,3000 Golvo 7000/7007 Golvo 7000 S/7007 S Golvo 7000 ES to S/N 7024205 Golvo 7007 ES to S/N 7729721 1. Prod. No. 20090044 3SE640266-02 2010-06-21 17 mm 2. 3. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 51 www.liko.com l www.hill-rom.com
5.40 Rear Wheel 125 mm Bakhjul 125 mm Lockable castor, d=125 mm 1 Nut M12 1 Golvo 1000,2000,3000 Golvo 7000/7007 Golvo 7000 S/7007 S Golvo 7000 ES to S/N 7024205 Golvo 7007 ES to S/N 7729721 Prod. No. 20090045 17 mm 1. 2. 3. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 52 www.liko.com l www.hill-rom.com
5.79 Plastic Housing Bandmagasin Plastic Housing 1 Locking pin 3x48 1 Golvo 7000/7007, 7000S/7007S Golvo 7000ES to S/N 7024205 Golvo 7007ES to S/N 7729721 Masterlift 2200, 2300 Likorall 240, 242, 242S, 242ES Prod. No. 31190008 3SE640289-03 2009-12-15 13 mm 1. Pull the strap all the way out. 2. Hold the springloaded wheel and release the strap by removing the pin. 3. Do not let go of the springloaded wheel, since the tension will release. 4. Use the pin to lock the axle where the strap was mounted. 5. Push the emergency lowering handle down and pull the strap away. 6. Pull the rest of the strap out and remove the plastic housing. 7. Mount the new strap through the plastic housing with the red mark towards the plastic housing and then as shown above. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 53 www.liko.com l www.hill-rom.com
5.79 Plastic Housing Bandmagasin Prod. No. 31190008 8. Remove the pin. Do not let go of the springloaded wheel, since the tension will release. Mount the strap through the slot in the axle and the same way back. Note! The axle has two different sides. Place the pin as shown to lock the strap. 9. Push the plastic housing on to the strap joint. 10. Roll the strap up. (Golvo: Until the red mark reaches the plastic housing) - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 54 www.liko.com l www.hill-rom.com
5.86 SlingBar Standard 450 Lyftbygel Standard 450 SlingBar Standard 450, incl cover with decals 1 Locking nut M10 nyloc 1 Screw K6S M10x25/15 1 MasterLift Likorall Golvo 7000 ES to S/N 7024205 Golvo 7007 ES to S/N 7729721 Caroli Uno (Uno 102 EE, up to S/N 51 999) Prod. No. 20190078 3SE650246-05 2013-03-20 17 mm 6 mm MasterLift: Golvo: Caroli: Uno, (Uno 102 EE up to S/N 51 999): 2x 17 mm 2x 10 mm Screw joints for Caroli and Uno are not included in this spare part. Use existing screw joint from the lift. If existing screw joints are worn or damage they need to be replaced by: Prod. No: 5019010 Overhead Beam Restoration set (Caroli) 20190074, Flexlink Alu (Uno) - Make sure the SlingBar is mounted in the same way as before dismounting. - It is of great importance that the screw is mounted all the way through the locking nut. - If the slingbar is binding or the cover hat will not fit, the screw is too tight. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Copyright Liko AB www.liko.com Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 55 www.liko.com l www.hill-rom.com
5.87 Latch Urkrokningsskydd Safety Latch 2 2001600 Golvo Mast Attachment for LikoStretch Mod 600 IC 3103603 Ultra SlingBar 20190078 SlingBar Standard 450 3156005 SlingBar Mini 220 3156006 SlingBar Mini 220 R2R 3156007 Sling Bar Std 450 Uno 3156009 Sling Bar Mini 220 Uno 3156013 Slingbar with extra lift-ing range 3156018 Sling Cross-bar 670 3156019 Sling Cross-bar 670 with Quick-release Hook 4.87.1 3156021 Sling Cross-bar 450 3156022 Sling Cross-bar 450 with Quick-release Hook 3156055 OctoStretch Saftey Latch 3156056 OctoStretch with Stretch Leveller Prod.no: 31190018 3156057 FlexoStretch 3156058 UltraStretch 2020020 Sabina 200 Urkrokningsskydd 2027002 Sabina II 350 SlingBar 2027003 Sabina II Comfort SlingBar, 600 mm (23.6 in) 2027006 Sabina SeatStrap SlingBar 2027007 Sabina II SeatStrap SlingBar Saftey Latch Urkrokningsskydd Doc. no: TI 31190018 2003-09-09 4.87.1 Prod. No. 31190018 3SE640271-06 2012-11-19 Prod.no: 31190018 Doc. no: TI 31190018 2003-09-09 1. 2. 3. - Pull up on the latch and make sure it falls to the closed position when released. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 56 www.liko.com l www.hill-rom.com
5.139 Extra Battery Box, incl Batteries Batteribox inkl batterier Battery box 1 Caroli Capella Golvo 7000 ES/7007 ES (all models), 7007 Low Base LikoLight Liko M220 / M230 Sabina Uno 100EM,EE,102EM,EE,ES Viking XL (Prod. No. 2040003) Viking L (Prod. No. 2040004) Viking M (Prod. No. 2040005) Prod. No. 2006106 3SE630224-06 2011-02-24 (Holder for the charging cable, is not standard on every lift model) 1 1 2 2 - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. - Old batteries are to be left at the nearest recycling station or given to personnel authorized by Liko. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 57 www.liko.com l www.hill-rom.com
5.159 Fork Cover Hjulkåpa Nylon screw M5x16 Nature 2 Front fork cover grey light 2 Golvo 7000 ES Golvo 7007 ES Golvo 7000 ES Classic / 7007 ES Classic Golvo 8000 / 8008 (all models) LikoLight Viking XL Viking L Viking M Viking S Viking XS Roll On Prod. No. 20390006 Document No. 183916 2013-10-10 4,2 mm M5 1. 2. 3. If not prepared with hole, drill [mm.] 38,4 M5 (drill Ø 4,2) 4. 22,25 5. 6. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 58 www.liko.com l www.hill-rom.com
5.160.1 Extension Cable Skarvkabel Extension cable EU 1 Golvo 7000ES/7007ES Golvo 7007 LowBase Uno 100 EM/EE Uno 102 EM/EE/ES Sabina EM/EE Sabina II EM/EE Viking XL (Prod. No. 2040003) Viking L (Prod. No. 2040004) Viking M (Prod. No. 2040005) Length 21 cm/ 8.5 inch Prod. No. 21090001 3SE630225-05 2011-03-02 1. 2. 3. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 59 www.liko.com l www.hill-rom.com
5.185 Lift Strap Golvo Lyftband Golvo Prod. No. 20090018, 20090019, 20090048 Lift strap 1 20090018 Golvo 7000/8000 20090019 Golvo 7007 up to S/N 7723629 20090048 Golvo 7007 from S/N 7723630, Golvo 8008 3SE650272-02 2011-11-03 3 and 4 mm Pull the strap all the way out. Hold the spring loaded wheel and release the strap by removing the pin. Remove the pin. Do not let go of the spring loaded wheel, or the tension will release. Use the pin to lock the axle where the strap was mounted. Push the emergency lowering handle down and pull away the strap. Pull out the rest of the strap an remove the plastic housing. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 60 www.liko.com l www.hill-rom.com
5.185 Lift Strap Golvo Lyftband Golvo Prod. No. 20090018, 20090019, 20090048 Mount the new strap through the plastic housing with the red mark towards the plastic housing and then as shown above. Mount the strap through the slot in the axle and back the same way. Note! The axle have two different sides. Place the pin as shown to lock the strap. Do not let go of the spring loaded wheel, or the tension will release. Push the plastic housing on to the strap joint. Roll up the strap until the red mark reaches the plastic housing. Assemble the Roll frame attachment Make sure the spare part is mounted according to the assembly instruction. After changing lift strap the Limit Switch must be tested by lifting maximum load all the way up to the highest position through the entire lifting range. Check all functions. Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 61 www.liko.com l www.hill-rom.com
5.218 Base Motor Cover, black Motorkåpa underrede, black Motor cover chassi, black 1 Cable grommet/holder 1 Screw MRX M5x90 2 Washer BRB 5.3x10x1 2 Golvo 7000 S/N 7021494-7024205 Golvo 7007 S/N 7722428-7729721 Prod. No. 20090049 3SE640278-03 2011-10-24 Tools required Remove cable from the old cover. Mount the cable and the new cover together with the plastic bushing. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 62 www.liko.com l www.hill-rom.com
5.250 Reinforcement Plate Golvo Bandstyrningsplåt Golvo Reinforcement plate 1 Screw K6s M5x10 Fzb 2 Golvo 7000 ES/7007 ES (all models) Golvo 7007 LowBase Golvo 8000/8008 (all models) Prod. No. 20090051 3SE630215-04 2010-05-04 3 mm 4,2 mm Remove the Roll frame attachment. 2 Assemble the Reinforcement Plate. Drill two holes Ø 4.2 mm in the housing using the holes in the Reinforcement Plate as guides. Secure with the two screws. 1 3 4 Assemble the strap joint: 5 6 7 8 9 10 - After changing reinforcement plate the SSP Limit Switch must be tested by lifting maximum load all the way up to the highest position through the entire lifting range. - With the emergency stop out, move the liftstrap all the way up against the SSP Limit switch. Check that the motor does not operate when touching the SSP Limit switch. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 63 www.liko.com l www.hill-rom.com
5.251 Limit switch G7/G77 Ändlägesbrytare G7/G77 Screw MCS M4x22mm 2 Limit switch trip wirefor 1 Spacer DRM 4380 2 Cable grommet 1 Electronic card limit switch 1 Golvo 7000ES/7007ES Golvo 7007 LowBase Prod. No. 20090052 3SE640240-03 2010-06-21 20090052 Limit switch G7-77 3. Remove the cover from the mast. 1. Remove cable from controlbox. 2. Push the plastic cover upwards. A Cable to controlbox Cable to actuator 4. Remove the cables from the electronic card. brown, blue, red, black 5. Loosen the electronic card by removing the screws, see picture 6, pull out the card. Loosen the screws holding the cables. 6. Assemble the new card. Make sure that the spacers (A) is between the mast and the card. Connect the cables. Make sure that the new card works by operating the actuator down at the same time as you press the Limit switch on the electronic card. Note: Some of the poles (+/ -) can be changed in older versions. The colours of the cable can be different than the picture shows. Always test the functionality after assembly. - ESD protection is required. - With the emergency stop out, move the liftstrap all the way up against the SSP Limit switch. Check that the motor does not operate when touching the SSP Limit switch. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 64 www.liko.com l www.hill-rom.com
5.263 Extension Cable, US Skarvkabel, US Extension cable US 1 Golvo 7000ES/7007ES Golvo 7007 LowBase Uno 100 EM/EE Uno 102 EM/EE/ES Sabina EM/EE Sabina II EM/EE Viking XL Prod. No. 2040003 Viking L Prod. No. 2040004 Viking M Prod. No. 2040005 Length 26.5 cm/ 10.5 inch Prod. No. 21090011 3SE630218-06 2011-05-02 1. 2. 3. - Repairs and maintenance may only be performed by personnel authorized by Liko/Hill-Rom and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 65 www.liko.com l www.hill-rom.com
5.264 Latch Universal Slingbar Urkrokningsskydd Universalbygel Latch 2 3156074 Universal SlingBar 350 3156075 Universal SlingBar 450 3156076 Universal SlingBar 600 3156077 Universal TwinBar 670 3156079 Universal SideBars 450 3156084 Universal SlingBar 350 with Quick-release Hook 3156085 Universal SlingBar 450 with Quick-release Hook 3156086 Universal SlingBar 600 with Quick-release Hook 3156087 Universal TwinBar 670 with Quick-release Hook 3156094 Universal SlingBar 350 R2R 3156095 Universal SlingBar 450 R2R Prod. No. 31590011 3SE630229-04 2011-05-25 - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 66 www.liko.com l www.hill-rom.com
5.274 Motor for Base width Adjustment Golvo, grey Motorpaket komplett Golvo, grå Motor for Base with Adjustment 1 Motor cable Mini Fit (for Golvo 8000/8008) 1 Prod. No. 20090059 3SE630216-05 2014-02-18 Golvo 7000/7007 (all models) Golvo 8000/8008 (all models) Golvo 7000/7007 (all models): 1. 2. 2,5 mm 4 mm Adjust the width almost to the outer position. Disconnect the motor cable from the control box 3. 4. 5. 6. A B D Assemble the Motor in reverse order. Connect the cable for base motor to socket number 3. C After mounting: The distance A & B must be the same. Note! The cover profiles (C) must be fixed to the middle beam (D). C - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 67 www.liko.com l www.hill-rom.com
5.275 Plastic housing, grey Bandmagasin, grå Cover spring magazine 1 Strap shaft emergency low 1 Screw K6S M5x12 1 Nut M6M M5 1 Screw TP WN1412 3x20 2 Spring magazine 1 Locking pin 3x48 1 Plastic housing knob rail 1 Prod. No. 20090060 3SE630267-02 2010-05-10 Golvo 7000ES from S/N 7024206 Golvo 7007ES from S/N 7729722 Golvo 7000ES Classic Golvo 7007ES Classic Golvo 7007 LowBase Golvo 8000/8008 (all models) Pull the strap all the way out. Hold the spring loaded wheel and release the strap by removing the pin. Do not let go of the spring loaded wheel, since the tension will release. Use the pin to lock the axle where the strap was mounted. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 68 www.liko.com l www.hill-rom.com
5.275 Plastic housing, grey Bandmagasin, grå Prod. No. 20090060 Push the emergency lowering handle down and pull the strap away. Pull the rest of the strap out and remove the plastic housing. Mount the strap through the new plastic housing with the red mark towards the plastic housing and then as shown above. Remove the pin. Do not let go of the spring loaded wheel, since the tension will release. Mount the strap through the slot in the axle and the same way back. Note! The axle has two different sides. Place the pin as shown to lock the strap. Push the plastic housing on to the strap joint. Roll the strap up until the red mark reaches the plastic housing. - After changing plastic housing the SSP Limit Switch must be tested by lifting maximum load all the way up to the highest position through the entire lifting range. - With the emergency stop out, move the lifts trap all the way up against the SSP Limit switch. Check that the motor does not operate when touching the SSP Limit switch. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 69 www.liko.com l www.hill-rom.com
5.279 Roll Frame Attachment G7/G77 G Rulländfäste G7/G77 G Prod. No. 20090064 3 mm 4 mm 8 mm 1. 2. 3. 4. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 70 www.liko.com l www.hill-rom.com
5.280 Base Motor Cover, grey Motorkåpa underrede, grå Motor cover chassi G7-77 1 Cable grommet/holder 1 Screw MRX M5x90 2 Washer BRB 5.3x10x1 2 Golvo 7000 ES fr. S/N 7024206 Golvo 7007 ES fr. S/N 7729722 Golvo 7007 Lowbase Golvo 7000 ES Classic / 7007 ES Classic Golvo 8000/8008 (all models) Prod. No. 20090065 3SE630270-02 2010-05-10 Tools required Remove cable from the old cover. Mount the cable and the new cover together with the plastic bushing. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 71 www.liko.com l www.hill-rom.com
5.284 Front Wheel 75 mm Framhjul 75 mm Front wheel 75mm 1 20390001 LikoLight (up to S/N 2503101) 20490014 Golvo 7000 (from S/N 7024206) Golvo 7007 (from S/N 7729722) Golvo 7000ES Classic / 7007 ES Classic Golvo 7007 LowBase Golvo 8000/8008 LikoLight (from S/N 2503102) RollOn Viking M 2040005 (from S/N 7102064) Viking M 2040015 Viking S Viking XS Prod. No. 20390001, 20490014 182904 Rev.1 2013-08-14 16 mm A) B) A&B) Mount the new spare part. Assemble in reverse order. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 72 www.liko.com l www.hill-rom.com
5.285 Rear Wheel 75 mm Bakhjul 75 mm Rear wheel 75mm 1 20390002 LikoLight (up to S/N 2503101) 20490015 Golvo 7000 (from S/N 7024206) Golvo 7007 (from S/N 7729722) Golvo 7000ES Classic / 7007 ES Classic Golvo 7007 LowBase Golvo 8000/8008 (all models) LikoLight (from S/N 2503102) RollOn Viking M 2040005 (from S/N 7102064) Viking M 2040015 Viking S Viking XS Prod. No. 20390002 20490015 182903 Rev.1 2013-08-14 16 mm A) B) A&B) Mount the new spare part. Assemble in reverse order. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 73 www.liko.com l www.hill-rom.com
5.292 5.292 Hook for HandControl 2, 4, 6 button Krok för handkontroll 2, 4, 6 knappar Prod. No. 20090058 Hook for Hand control 2,4,6 1 20090089 HandControl 6-button 20190016 HandControl EE 4-button 20190017 HandControl EM 2 button 3SE630210-06 2012-10-16 T10 - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 74 www.liko.com l www.hill-rom.com
5.293 End Cover Handle/Arm Support, grey Ändplugg handtag/armstöd, grå End Cover, grey 4 Golvo 7000ES from S/N 7024206 Golvo 7007ES from S/N 7729722 Golvo 7000ES / 7007ES (Classic) Golvo 7007 LowBase Golvo 8000/8008 (all models) LikoLight Viking XL Viking L Viking M Viking S Viking XS RollOn Prod. No. 20090066 3SE630271-01 2010-04-29 - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 75 www.liko.com l www.hill-rom.com
5.294 End Cover Armrest, grey Gavel för armhållare, grå Endcover armrest Grey 2 Screw MRX M5x10 Ezloc 4 Washer BRB 5,3x10x1 4 Golvo 7000ES from S/N 7024206 Golvo 7007ES from S/N 7729722 Golvo 7007 LowBase Golvo 8000/8008 (all models except Classic) Viking L, XL Armrest Viking M Armrest Prod. No. 20090067 3SE630272-01 2010-05-18 3 mm 1. 2. 3. 4. 5. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 76 www.liko.com l www.hill-rom.com
5.294 End Cover Armrest, grey Gavel för armhållare, grå Prod. No. 20090067 6. 7. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 77 www.liko.com l www.hill-rom.com
5.311 Latch, composite Urkrokningsskydd komposit Latch composite 2 From S/N: 3156074 Universal SlingBar 350 1299511 3156075 Universal SlingBar 450 1299511 3156076 Universal SlingBar 600 1299511 3156077 Universal TwinBar 670 1299511 3156079 Universal SideBars 450 1299511 3156084 Universal SlingBar 350 with Quick-release Hook 1299511 3156085 Universal SlingBar 450 with Quick-release Hook 1299511 3156086 Universal SlingBar 600 with Quick-release Hook 1299511 3156087 Universal TwinBar 670 with Quick-release Hook 1299511 3156094 Universal SlingBar 350 R2R 1299511 3156095 Universal SlingBar 450 R2R 1299511 20590006 SlingBar Liko 450 1700101 Prod. No. 31590014 3SE640242-05 2011-02-22 The Latch can only be used on composite hooks equipped with a locator. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 78 www.liko.com l www.hill-rom.com
5.323-324 Easy Strapper G7/G8, G77/G88 Monteringssats komplett lyftband G7/G8, G77/G88 Now with grey strap and grey plastic details. 20090069 Easy strapper G7/G8 1 Golvo 7000 Golvo 7000 ES Classic Golvo 8000 (all models) 20090070 Easy strapper G77/G88 1 Golvo 7007 from S/N 7723630 Golvo 7007 ES Classic Golvo 7007 LowBase Golvo 8008 (all models) Prod. No. 20090069, 20090070 3SE640248-03 2011-03-30 3mm 13mm 1. 2. 4. Mount the spare part, assemble in reverse order. 3. - After changing lift strap the Limit Switch must be tested by lifting maximum load all the way up to the highest position through the entire lifting range. - With the emergency stop out, move the liftstrap all the way up against the Limit switch. Check that the motor does not operate when touching the Limit switch. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 79 www.liko.com l www.hill-rom.com
5.330 Golvo 7007/8008 LowBase kit Golvo 7007/8008 LowBase bensats Coverage list Lowrider 2 Leg alu right 1 Leg alu left 1 Leg adapter 2 Wheel housing Golvo LowR 2 Wheel axle 12x64 Golvo Lo 2 Leg LowRider 2 Wheel D50 Golvo LowRider 4 Leg clip 2 Bearing 10/12x10 2 Bearing Nylonit 10/12/12 2 Ball bearing 6000-2Z/C3 4 Locking nut M8 Nyloc fzb 8 Screw MC6S M8x30mm Ezloc 2 Stop screw S6SS M6x10 2 Tape 25x25 G7 4 Screw F6S M8x25 2 Retaining ring SGH26 4 Plastic cover IKPT 28 26 4 O-ring 9x1 2 Ball Class IV RB 6.35 LR 2 Prod. No. 20090071 3SE640262-02 2010-05-10 4 mm 5 mm 13 mm 17 mm Golvo 7007 (all models) Golvo 8008 (all models) 1. Remove rear wheel and leg. (left and right) Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 80 www.liko.com l www.hill-rom.com
5.330 Golvo 7007/8008 LowBase kit Golvo 7007/8008 LowBase bensats Prod. No. 20090071 2. Assemble the legs with screws, nuts, plastic covers and washers from the lift. 3. Assemble the rear wheels with stop screw. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 81 www.liko.com l www.hill-rom.com
5.397 Q-link Lift strap joint 1 Strap joint plastic cover 1 Lift strap safety pin 4 mm 1 Extension belts Golvo 7000/7007 Golvo 8000/8008 Likorall Multirall 200 1 X Prod. No. 31590005 3SE640236-02 2010-05-10 Tools required Important! For safety reasons, it is essential that this component is correctly fitted to the lift according to these instructions. Disassemble: 1a. alt: 1b. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 82 www.liko.com l www.hill-rom.com
5.397 Q-link Prod. No. 31590005 Assemble: 2. 3. 4. 5. 6. 7. - After changing Q-link, the assembly must be tested by lifting maximum load all the way up to the highest position. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 83 www.liko.com l www.hill-rom.com
5.398 Lift strap joint Bandlås med hål Lift strap joint 1 Strap joint plastic cover 1 Lift strap safety pin 4mm 1 Golvo 7000/7007 Golvo 8000/8008 Likorall 1 X Prod. No. 31590025 3SE640237-02 2010-05-10 Tools required Important! For safety reasons, it is essential that this component is correctly fitted to the lift according to these instructions. Disassemble: 1a. alt: 1b. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 84 www.liko.com l www.hill-rom.com
5.398 Lift strap joint Bandlås med hål Prod. No. 31590025 Assemble: 2. 3. 4. 5. 6. 7. - After changing Lift strap joint, the assembly must be tested by lifting maximum load all the way up to the highest position. - Repairs and maintenance may only be performed by personnel authorized by Hill-Rom/Liko and using original Liko spare parts. Service Manual Golvo 7000/7007 mobile lift (3EN400401 Rev. 8) 85 www.liko.com l www.hill-rom.com