Electronic GPS Dropsonde System Installation. Electrical Loads Analysis Report: ELA-AVAPS-100

Transcription

1 National enter for tmospheric Research lectronic GPS ropsonde System Installation lectrical Loads nalysis Report: L-VPS-100 NS Gulfstream V ircraft, SN 677 Revision: (initial release) ate: 25 October 2005 National enter for tmospheric Research Research Technology acility 3450 Mitchell Lane oulder, olorado Prepared y: Terry Hock ngineer National enter for tmospheric Research 2005 University orporation for tmospheric Research isclosure of information contained herein may only be made to UR or personnel and/or esignees to support this certification effort. isclosure to other persons requires the express written consent of UR Legal ounsel. VPS lec load analy Rev.doc

2 Report L-VPS-100 Rev, Initial release ii lectronic GPS ropsonde System Rack Installation lectrical Loads nalysis Report: L-VPS-100 Revision Revision ate escription Pages pproved ate 25 Oct 05 Initial Release ll UR onfidential and Proprietary Information

3 Report L-VPS-100 Rev, Initial release iii NR ropsonde System lectrical Loads nalysis NS Gulfstream V ircraft, SN 677 TL O ONTNTS 1. INTROUTION SRIPTION RSRH SYSTM RSRH QUIPMNT IRUIT PROTTION LO NLYSIS ONLUSION...3 LIST O TLS Table 1 ropsonde quipment List...2 Table 2 ircuit reaker ata...2 Table 3 Power Load Summary...3 LIST O IGURS igure 1 lock diagram of power distribuiton for HIPR ropsonde Instrument...4 UR onfidential and Proprietary Information

4 Report L-VPS-100 Page 1 of 4 Rev 1. Introduction NR is developing main cabin equipment (M) racks to support atmospheric research equipment installations on the National Science oundation (NS) GV aircraft, SN677, under ST project number ST3285-T through the OT- enver O. Research power wiring was previously installed by Lockheed Martin ircraft ompany IW ST ST03056T. Research equipment will not interface with existing aircraft systems, nor will the equipment provide information to the flight crew to assist them with operation of the aircraft. Therefore, (Guidance for the Installation of Miscellaneous, Non-required lectrical quipment) will be utilized to show compliance with the applicable regulations of 14 R Part 25. This report will present the data for the electrical load analysis of the ropsonde Instrumentation rack. This report is for the electrical load analysis for the ropsonde System atmospheric instrumentation equipment installed in an instrumentation rack in the main cabin area. Items installed in the rack are ommercial Off The Shelf (OTS) equipment. There are four items which use aircraft power; 1) P Rack Mount omputer, 2) L lat Panel Monitor, 3) Telemetry chassis and 4) 28 volt Power Supply. ll equipment in the ropsonde instrumentation rack does not interface with existing aircraft systems, nor do they provide information to the flight crew to assist them with operation of the aircraft. Therefore, the miscellaneous, non-required electrical equipment and the guidance of have been utilized. 2. escription 2.1. Research System The research electrical system is designed to provide 40KV of 115 V 400HZ 3 phase power continuously from the two Integrated rive Generators (IGs) for research applications. Twenty KV from each IG is allocated for Mission power. The aircraft uses frequency converters located in the Main Power istribution ox (MP) to convert the 400 HZ to 21KV of 110 V 60 HZ 1 Phase as supplied by the manufacturer. Research power distribution and controls are located in the MP as supplied by the manufacturer. The maximum allowable continuous electrical load for each power source is 20 amps Research quipment The ropsonde system consists of the following equipment: ropsonde instrumentation rack using 115 V 60 amps. The unit is protected by the existing #330311, a 20 amp breaker located in the MP. Table 1 lists the individual components contained in the dropsonde instrument rack. Several of the units are protected by an independent circuit breakers, see table 2. ropwindsonde Launcher ssembly, manufactured by eromet/l3 ommunications Inc., model number The unit is powered by 28 Vdc from the ropsonde instrumentation rack. The wiring UR onfidential and Proprietary Information

5 Report L-VPS-100 Page 2 of 4 Rev harness between the instrumentation rack and launch tube is protected by a 20 amp circuit breaker located in the ropsonde instrument rack. UH ircraft blade antenna, Manufactured by Sensor Systems Inc., model number S This is a passive device and does not consume power. The ropsonde research instrumentation rack consists of the following commercial off the shelf (OTS) equipment: listed in Table 1 Table 1 ropsonde quipment List Item escription Manufacture Model Input Voltage 1 P omputer PS 2USP43 120V 60Hz 2 L Monitor Interlogic Industries R19X-SH 120V 60Hz 3 Telemetry hassis/ooling an NR VPS hassis 120V 60Hz 4 28Vdc Power Supply Vicor VP V 60Hz 5 Launch tube control Panel NR wg No Vdc VPS Keyboard yber Research OIX 1910-P N 7 Sonde Storage box NR wg No VPS-1-3 N block diagram (wg. No. VPS ) of the and power system is included at the end of the report of the ropsonde installation. Table 2 ircuit reaker ata Item escription ircuit reaker Rating Mill-Spec Part No. 1 ooling an 2 amps MS Telemetry hassis 1 amps MS Vicor Power Supply 5 amps MS ircuit Protection The equipment rack installed is individually protected by circuit breakers or by a shared breaker installed by the manufacturer in the MP, the breaker shall not exceed 20 mps. The circuit breakers are of the same type as installed by the manufacturer as original equipment Load nalysis elow in table 1 is a list of all devices in the ropsonde Instrumentation rack that is power by the aircraft 110 V 60Hz power system. The equipment has built in circuit breaker protection for each individual item listed in table 1. The maximum total current load under any condition is 11.7 amps. UR onfidential and Proprietary Information

6 Report L-VPS-100 Page 3 of 4 Rev Item escription Power able Type 1 omputer 3-wire 16 gauge 2 Monitor 3-wire 16gauge 3 Telemetry hassis/ ooling an 4 Vicor Power Supply Table 3 Power Load Summary Tabulation of power values Power 60 Hz for all units listed 3-wire 16 gauge 3-wire 16 gauge verage urrent (mps) Peak urrent (mps) Power Not to xceed (Watts) Unit ircuit reaker (mps) None None Total 2.0 mps 5.9 mps 1000 Watts 7 mps The maximum electrical load current at 120V 60HZ of the ropsonde Instrument rack is 5.9 amps. This load allows for a safety margin of 14.1 amps (or 70.5 %) from the 20 amp circuit for the M. 3. onclusion The basic research rack system as installed by NR is a stand alone independent system that interfaces to the Lockheed Martin ircraft enter as part of ST number ST03056T research electrical system. This research power distribution system incorporates automatic load shedding and a cockpit kill switch for the research power system. Independent circuit breakers protect all of the rack installed equipment and are of the type supplied as original equipment by the manufacturer. The system loads cannot exceed 20 amps per circuit. ll the circuit breakers are accessible to the flight crew at the Main Power istribution ox. The basic research systems do not interface with existing aircraft systems, nor do they provide information to the flight crew to assist them with operation of the aircraft. Therefore, all basic research system equipment can be considered miscellaneous, non-required electrical equipment and the guidance of has been utilized. UR onfidential and Proprietary Information

7 Report L-VPS-100 Page 4 of 4 Rev igure 1 lock diagram of power distribution for HIPR ropsonde Instrument UR onfidential and Proprietary Information

8 Main Power istribution ox (xisting) 60 Hz reakout Power ox RV. SRIPTION T Y Initial Release 9/2/05 TH Right abin SPR 120 V 60 HZ reaker "" 20 mp V 60 Hz 120 V 60 Hz 120 V 60 Hz POWR NOT TO X 350W PS omputer Model No. 2USP V 60 Hz NR wg. No V 60 Hz POWR NOT TO X 50W L Monitor Model No. R19X-SH POWR NOT TO X 100W 2.0 amp P/N: MS NR ropsonde Telemetry an Unit 120 V 60 Hz 1.0 amp P/N: MS NR ropsonde Telemetry hassis POWR NOT TO X 700W POWR NOT TO X 450W 5.0 amp P/N: MS Power Supply 28Vdc Model No. Vicor VP Vdc ropwindsonde Launcher ssembly Part No R. L SRIPTION Power 3-wire 16 gauge Power 3-wire 16 gauge Power 3-wire 16 gauge Power 3-wire 16 gauge Power 3-wire 16 gauge NR wg. No. 677VPS VPS VPS VPS VPS-3-02 Power 2-wire 16 gauge, 3-wire 22 gauge 677VPS-3-05 opyright 2005 University orporations for tmospheric Research, ll rights reserved. ONINTIL, ny unauthorized use, coping or distribution is prohibited. NG: T. Hock 9/2/05 National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O HIPR ropsonde Power istribution lock iagram SIZ ile SM Name: NO WG NO RV HIPR L iagram 677VPS Rev SL 1 : 1 SHT 1 O 1

9

10

11

12

13

14

15

16

17 ' ' ' ' ' ' '' ' ' / %=- " / /5%4,! '' / ' : / 9: 9: 9 / 9:' : / 9: ' ' 9:' 9: ' / 9: ' : / : 9 9 / " /5%4, #4#< / /5%4, )#0 #&8, %*&=3,) 9 / %=-! &8,)5##) / /: 9: /9: ' 9: /9:' : 5,>*.0<,&4.66*005.,8+143,*6,) 3,?#)$%)8)#*4,.6?#)#&,@%&4,&&%=%+5,/(' 43,/=%+5,/(2#,64#43,//5%4, %&843,%?4)#*4,.6?#)%=#&4)#5=%+5,=#&6.6.4.&2#? 43),,@.5:: (::4$#@.5:: (:: %&8#&,@=%+5,/('::' /9 : 9 :' ' 9: ' /9: ' ; '! #$%& '('(' " )$.& '((' ")*+,- '((' 6,5##) /%663)#*23 / /! #01).234'' 5).2346),6,)7,8

18 Main Power istribution ox (xisting) 60 Hz reakout Power ox RV. SRIPTION T Y Initial Release 9/2/05 TH Right abin SPR 120 V 60 HZ reaker "" 20 mp V 60 Hz 120 V 60 Hz 120 V 60 Hz POWR NOT TO X 350W PS omputer Model No. 2USP V 60 Hz NR wg. No V 60 Hz POWR NOT TO X 50W L Monitor Model No. R19X-SH POWR NOT TO X 100W 2.0 amp P/N: MS NR ropsonde Telemetry an Unit 120 V 60 Hz 1.0 amp P/N: MS NR ropsonde Telemetry hassis POWR NOT TO X 700W POWR NOT TO X 450W 5.0 amp P/N: MS Power Supply 28Vdc Model No. Vicor VP Vdc ropwindsonde Launcher ssembly Part No R. L SRIPTION Power 3-wire 16 gauge Power 3-wire 16 gauge Power 3-wire 16 gauge Power 3-wire 16 gauge Power 3-wire 16 gauge NR wg. No. 677VPS VPS VPS VPS VPS-3-02 Power 2-wire 16 gauge, 3-wire 22 gauge 677VPS-3-05 opyright 2005 University orporations for tmospheric Research, ll rights reserved. ONINTIL, ny unauthorized use, coping or distribution is prohibited. NG: T. Hock 9/2/05 National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O HIPR ropsonde Power istribution lock iagram SIZ ile SM Name: NO WG NO RV HIPR L iagram 677VPS Rev SL 1 : 1 SHT 1 O 1

19 To: Telemetry hassis RV. SRIPTION T Y Initial Release 10/19/05 TH P1: RVR/PTU UR #1 P5: MWG # Label I: P/SRIL/ Label I: P/SRIL/ P2: RVR/PTU UR #2-9 Label I: P/SRIL/ omputer Signal able P6: MWG #2-9 Label I: P/SRIL/ Male P3: RVR/PTU UR #3-9 Label I: P/SRIL/ P7: MWG #3-9 Label I: P/SRIL/ P4: RVR/PTU UR #4 P8: MWG # Label I: P/SRIL/ Label I: P/SRIL/ To: omputer -78 Port (#1 Lower onnector) 39" R Qty SRIPTION PRT NO. MNUTUR 2 Video omputer able WhyteHaus ables opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. omputer Octopus Serial able to Telemetry hassis NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-14 SL 1 : 1 SHT 1 O 2

20 To: Telemetry hassis RV. SRIPTION T Y Initial Release 10/19/05 TH P9: Telemetry Log Rcvr -9 Label I: P/SRIL/ P10: Sonde Interface -9 Label I: P/SRIL/ P105: MWG SK MO #1-9 Label I: P/SRIL/ omputer Signal able P106: MWG SK MO #2-9 Label I: P/SRIL/ Male P107: MWG SK MO #3-9 Label I: P/SRIL/ P108: MWG SK MO #4-9 Label I: P/SRIL/ Null Modem (M9 male) Null Modem (M9 male) -9-9 Label I: P/SRIL/ Label I: P/SRIL/ To: omputer -78 Port (#2 Upper onnector) 39" opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. omputer Octopus Serial able to Telemetry hassis NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-14 SL 1 : 1 SHT 2 O 2

21 RV. SRIPTION T Y Initial Release 10/19/05 TH To: omputer Keyboard Plug PS-2 Male Pink Label I: P/K&MOUS Male omputer Signal able To: omputer Mouse Plug PS-2 Male Green 42" Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 Keyboard/Mouse omputer able/keyboard U-5K Ikeu opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. Keyboard/Mouse able NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-13 SL 1 : 1 SHT 1 O 1

22 RV. SRIPTION T Y Initial Release 10/19/05 TH Label I: MONITOR/VIO Male -15 Male To: omputer Video Port omputer Signal able To: Monitor Video Port 60" Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 Video omputer able VNPS MM lack ox Network Services. opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. omputer Video Monitor able NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-12 SL 1 : 1 SHT 1 O 1

23 RV. SRIPTION T Y Initial Release 10/19/05 TH 120V POWR PLUG Label I: MONITOR/120V-3-11 HOT GROUN RTURN R LK WHIT Plug PLUG SI VIW NOT: SHIL NOT US ttaches To: Monitor ttaches To: Power Terminal Strip 54" Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 onnector, Power / Plug, Hospital grade, 15/125V HL8215 Hubbell 1 3 conductor 16 gauge wire Teflon insulation STT T-1929(3) STJ TYP THRMX 1 onnector, POWR PLUG / 3-circuit SHURTR opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Power able, Monitor NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-11 SL 1 : 1 SHT 1 O 1

24 RV. SRIPTION T Y Initial Release 10/19/05 TH R SM onnector Label I: LNHR/GPS-3-10 R SM onnector ttaches To: GPS Power ivider ttaches To: GPS ntenna 12.5" Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 2 SM R ONNTORS P WIR & L 1 50 ohm OX S44191 P WIR & L opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde GPS R able, Sonde Storage ox NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV HIPR L iagram Rev 677VPS-3-10 SL 1 : 1 SHT 1 O 1

25 RV. SRIPTION T Y Initial Release 10/19/05 TH R TN onnector Label I: HSSIS/GPS-3-09 R TN onnector 25.75" ttaches To: Sonde Storage ox ttaches To: Telemetry hassis Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 2 TN R ONNTOR P WIR & L 1 50 ohm OX S44191 P WIR & L opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde GPS R L, Sonde Storage ox to Telemetry hassis NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-09 SL 1 : 1 SHT 1 O 1

26 RV. SRIPTION T Y Initial Release 10/19/05 TH 120V POWR PLUG Label I: P/120V-3-08 HOT GROUN RTURN R LK WHIT Plug PLUG SI VIW NOT: SHIL NOT US ttach To: omputer ttach To: Power Terminal Strip 39" R Qty SRIPTION PRT NO. MNUTUR Note: pply label I within 6" of each end and at 5' increments 1 onnector, Power / Plug, Hospital grade, 15/125V HL8215 Hubbell 1 3 conductor 16 gauge wire Teflon insulation STT T-1929(3) STJ TYP THRMX 1 onnector, POWR PLUG / 3-circuit SHURTR opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Power able, OMPUTR NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-08 SL 1 : 1 SHT 1 O 1

27 RV. SRIPTION T Y Initial Release 10/25/05 TH MS ircular onnector ttaches to 28V Power Supply G H I J K L M N O 5" 8" 10.5" 28 V RM SOLNOI 28V 28V LUNH SOLNOI GROUN VLV OPN SIGNL Label I: LNHR/28V " 8" 10.5" G.... R S MS ircular onnector ttaches To: ropwindsonde Launcher ssembly inal length to be determined upon installation (Shall not exceed 30 ) R Qty SRIPTION PRT NO. MNUTUR Note: pply label I within 6" of each end and at 5' increments 1 onnector, MS ircular / MIL circuit MS S ITT annon 1 1 conductor 22 gauge wire, TLON WHIT M22759/1619W THRMX 1 1 conductor 16 gauge wire, TLON WHIT M22759/161619W THRMX 1 onnector, MS ircular / MIL circuit MS S ITT annon 6 rimp wire connector, covered with heat shrink tubing S18 3M opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Launcher ontrol able, to ropwindsonde Launcher ssembly NG: T. Hock 10/25/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-07 SL 1 : 1 SHT 1 O 1

28 RV. SRIPTION T Y Initial Release 10/19/05 TH R TYP "N" onnector Label I: HSSIS/400MHZ-3-06 R TYP "N" onnector ttaches To: 400 MHz UH lade ntenna ttaches To: Telemetry hassis Length to be determined upon installation (Shall not exceed 75 ) Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 2 TYP N R ONNTORS P WIR & L 1 50 ohm OX, RG-8 TYP S22089 P WIR & L opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde R OX L, UH NTNN NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-06 SL 1 : 1 SHT 1 O 1

29 Label I: LNHR/28V-3-05 RV. SRIPTION T Y Initial Release 9/7/05 TH MS ircular onnector ttaches to 28V Power Supply G H I J K L M N O 28 V RM SOLNOI 28V 28V LUNH SOLNOI GROUN VLV OPN SIGNL G H I J K L M N O P Q R S MS ircular onnector ttaches to Launch ontrol Panel 55" Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 onnector, MS ircular / MIL circuit MS S ITT annon 1 1 conductor 22 gauge wire, TLON WHIT M22759/1619W THRMX 1 1 conductor 16 gauge wire, TLON WHIT M22759/161619W THRMX 1 onnector, MS ircular / MIL circuit MS S ITT annon opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Launcher ontrol able, Launch ontrol Panel to 28V Power Supply NG: T. Hock 9/7/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-05 SL 1 : 1 SHT 1 O 1

30 RV. SRIPTION T Y Initial Release 9/7/05 TH Label I: PS/28V-3-04 MS ircular Male onnector 28 Vdc GROUN NOT: SHIL NOT US R LK MS ircular onnector ttach to 28V Power Supply, Input ttach to Launch ontrol Panel 59" R Qty SRIPTION PRT NO. MNUTUR Note: pply label I within 6" of each end and at 5' increments 1 onnector, MS ircular / MIL circuit Male S-6P ITT annon 1 3 conductor 16 gauge wire Teflon insulation STT T-1929(3) STJ TYP THRMX 1 onnector, MS ircular / MIL circuit S-6S ITT annon opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Power able, 28 Vdc Power Supply to Launch ontrol Panel NG: T. Hock 9/7/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-04 SL 1 : 1 SHT 1 O 1

31 RV. SRIPTION T Y Initial Release 9/7/05 TH 120V POWR PLUG Label I: PS/120V-3-03 HOT GROUN RTURN R LK WHIT MS ircular onnector PLUG SI VIW NOT: SHIL NOT US ttach to 28V Power Supply, Input 13" ttach to Terminal Strip Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 onnector, Power / Plug, Hospital grade, 15/125V HL8215 Hubbell 1 3 conductor 16 gauge wire Teflon insulation STT T-1929(3) STJ TYP THRMX 1 onnector, MS ircular / MIL circuit S-7S ITT annon opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Power able, 28 Vdc Power Supply NG: T. Hock 9/7/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-03 SL 1 : 1 SHT 1 O 1

32 RV. SRIPTION T Y Initial Release 9/7/05 TH Label I: HSSIS/120V-3-02 MS ircular Male onnector HOT GROUN RTURN R LK WHIT MS ircular onnector ttach to ooling an NOT: SHIL NOT US 13.5" ttach to Telemetry hassis Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 onnector, MS ircular / MIL circuit Male S-7P ITT annon 1 3 conductor 16 gauge wire Teflon insulation STT T-1929(3) STJ TYP THRMX 1 onnector, MS ircular / MIL circuit S-7S ITT annon opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Power able, ooling an unit to Telemetry hassis NG: T. Hock 9/7/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-02 SL 1 : 1 SHT 1 O 1

33 RV. SRIPTION T Y Initial Release 10/19/05 TH 120V POWR PLUG Label I: NS/120V-3-01 HOT GROUN RTURN R LK WHIT MS ircular onnector PLUG SI VIW NOT: SHIL NOT US ttaches to ooling an Input ttaches to Terminal Strip 31" Note: pply label I within 6" of each end and at 5' increments R Qty SRIPTION PRT NO. MNUTUR 1 onnector, Power / Plug, Hospital grade, 15/125V HL8215 Hubbell 1 3 conductor 16 gauge wire Teflon insulation STT T-1929(3) STJ TYP THRMX 1 onnector, MS ircular / MIL circuit S-7S ITT annon opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab (OL) 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde Power able, ooling an NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV 677VPS-3-01 SL 1 : 1 SHT 1 O 1

34 RV. SRIPTION T Y Initial Release 9/2/05 TH H H G L Monitor Video Input Video Signal Power 120V 60 Hz 3-wire Input Power 120V 60 Hz 3-wire Power Strip H K Power 120V 60 Hz 3-wire R. G H I J K L M N O rawing Number 677VPS VPS VPS VPS VPS VPS VPS VPS VPS VPS VPS VPS VPS VPS VPS-3-15 G L P omputer Keyboard M Input Video RJ-45 Network Keyboard RS-232 Signal N I OX GPS R Power ivider To ircraft ata System OX Sonde Storage ox J OX GPS ntenna IRRT GPS R SIGNL Telemtry hassis ooling an RVR/PTU uffer Input MWG Log Rcvr Sonde Interface MWG P1 ata MWG SK emod GPS nt 400 MHz nt OX Output Input Power 120V 60 Hz 3-wire opyright 2005 University orporations for tmospheric Research, ll rights reserved. OX 400 MHz UH L NTNN National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O O ROPWINSON LUNHR ONINTIL, ny unauthorized use, coping or distribution is prohibited. NG: T. Hock 9/2/05 HIPR ROPSON INSTRUMNTTION SSMLY WIRING IGRM SIZ ile SM Name: NO WG NO RV VPS-2-02 SL 1 : 1 SHT 1 O

35 RV. SRIPTION T Y Initial Release 9/2/05 TH H H G LUNH ONTROL PNL G VIOR 28V SUPPLY ROPSON ISPNSR MOUNT ON RONT O INSTRUMNT RK 28 Vdc POWR SUPPLY MOUNT ON RR O INSTRUMNT RK 120V INPUT 28V OUT ONTROL PNL ISPNSR Power 120V 60 Hz 3-wire G TO ROPWINSON LUNHR SSMLY Power Strip MOUNT ON RR O INSTRUMNT RK opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. NG: T. Hock 9/2/05 HIPR ropsonde ssembly Wiring iagram SIZ ile SM Name: NO WG NO RV HIPR L iagram Rev VPS-2-02 SL 1 : 1 SHT 2 O

36 RV. SRIPTION T Y Initial Release 10/26/05 TH H GPS R Signal xisting R oax H Sonde Storage ox (GPS Power ivider) H R oax wg. 677VPS Label I: GPS/LNHR-3-15 H 400 MHz R Signal H wg. 677VPS R oax I J I G 120 V 120 V ooling an wg. 677VPS-3-01 Power Label I: NS/120V-3-01 wg. 677VPS Power Label I: MONITOR/120V-3-11 wg. 677VPS Power L Monitor R oax wg. 677VPS Label I: LNHR/GPS-3-10 K Label I: HSSIS/400MHZ-3-06 Label I: HSSIS/120V-3-02 Video Signal Label I: HSSIS/GPS-3-09 wg. 677VPS I R oax H M Telemetry hassis R. G H I J K L M N O P ONNTOR TYP, SRIPTION Power Plug, 3-circuit Power, MS ONNTOR 3-PIN ML Power, MS ONNTOR 3-PIN ML Power, MS ONNTOR 6-PIN ML Power & SIGNL, MS ONNTOR 6-PIN ML Power & SIGNL, MS ONNTOR 15-PIN ML Power & SIGNL, MS ONNTOR 19-PIN ML R SIGNL, TYP N ML R ONNTOR R SIGNL, TN ML R ONNTOR R SIGNL, SM ML R ONNTOR VIO SIGNL, 15-PIN ML ONNTOR RS-232 OMPUTR SIGNL, 80-PIN ONNTOR RS-232 SIGNL, 9-PIN ML ONNTORS OMPUTR SIGNL, 15-PIN ML ONNTOR NTWORK SIGNL, 6-PIN, RJ-45 ONNTOR PSSIV GPS NT., P/N: L1RRKP-S, GPS Networking Inc. G Location: aggage compartment area wg. 677VPS Label I: MONITOR/VIO-3-12 wg. 677VPS omputer RS-232 Signal Label I: P/SRILXX-3-14 J P Passive GPS ntenna P/N. L1RRKP-S 120 V omputer Network wg. 677VPS Power Label I: P/120V-3-08 xisting Network able O P omputer K L N N wg. 677VPS omputer Signal Label I: P/K&MOUS-3-13 Keyboard ropwindsonde Launcher ssembly Part No wg. 677VPS Vdc Label I:LNHR/28V-3-07 G 120 V wg. 677VPS Power Label I: PS/120V Vdc Power Supply wg. 677VPS Vdc Label I:LNHR/28V-3-05 wg. 677VPS Vdc Launch ontrol Panel Label I: PS/28V-3-04 opyright 2005 University orporations for tmospheric Research, ll rights reserved. ONINTIL, ny unauthorized use, coping or distribution is prohibited. NG: T. Hock 10/26/05 National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O HIPR ropsonde Instrumentation lock Wiring iagram SIZ ile SM Name: NO WG NO RV HIPR ropsonde VPS-2-01 lock Wiring 677VPS-2-01 SL 1 : 1 SHT 1 O

37 RV. SRIPTION T Y Initial Release 10/19/05 TH R TN onnector Label I: GPS/LNHR-3-15 R SM onnector ttaches To: GPS Power ivider ttaches To: GPS ntenna Length to be determined at install Shall not exceed 30' Note: pply label I within 6" of each end and at 5' increments R P WIR & L able ssembly Part No Qty SRIPTION PRT NO. MNUTUR 1 SM R ONNTORS P WIR & L 1 50 ohm OX S44191 P WIR & L 1 TN R ONNTOR P WIR & L opyright 2005 University orporations for tmospheric Research, ll rights reserved. National enter for tmospheric Research arth Observing Lab 3450 Mitchell Lane, oulder O ONINTIL, ny unauthorized use, coping or distribution is prohibited. HIPR ropsonde GPS R able, Launcher GPS Reradiating ntenna NG: T. Hock 10/19/05 SIZ ile SM Name: NO WG NO RV HIPR L iagram Rev 677VPS-3-15 SL 1 : 1 SHT 1 O 1